An insight into the electrochemical performance of La0.5-: XPrxBa0.5CoO3- δ as cathodes for solid oxide fuel cells: Study of the O2-reduction reaction

GARCÉS, D.; WANG, H.; BARNETT, S.A.; LEYVA, A.G.; NAPOLITANO, F.R.; FUENTES, R.O.; TROIANI, H.E.; MOGNI, L.V.

Journal of Materials Chemistry A

Royal Society of Chemistry

Año: 2018 vol. 6 p. 16699 - 16709

2050-7488

New LT-SOFC cathodes with La0.5-xPrxBa0.5CoO3-δ (0 ≤ x ≤ 0.5) compositions were studied. The La-rich compounds exhibit an inter-growing cubic and tetragonal structure whereas the Pr-rich show a tetragonal structure. Cathode polarization resistances, estimated from electrochemical impedance (EIS), take values around 0.15 and 0.04 Ω cm2 in air at 600 and 700 °C, respectively. The O2-reduction mechanism and its kinetic coefficients, O-ion diffusion (Dchem) and O-surface exchange (kchem), were studied by applying the ALS model for macro homogenous porous electrodes to the EIS data, in combination with microstructural parameters obtained from three-dimensional tomography using focused ion beam-scanning electron microscopy (3D FIB-SEM). The diffusion coefficients for samples with mixing of phases take values of Dchem ∼ 10-6 cm2 s-1, at 700 °C in air, whereas the pure tetragonal phases present lower values Dchem ∼ 10-8 cm2 s-1. On the contrary the kchem for all samples takes values ranging between 0.4 and 1 × 10-4 cm s-1 at 700 °C in air. In addition, the origin of time evolution of polarization at 700 °C in air was evaluated by combining the EIS spectra as a function of time and the ex situ sample characterization of fresh and tested samples by 3D FIB-SEM tomography and inductively coupled plasma-optical emission spectrometry (ICP-OES). Little changes of microstructures were detected, whereas an increasing of the amount of a water-soluble Ba surface species in comparison with total cation surface segregation was observed for all samples after the ageing. This may constitute the main reason causing the polarization resistance degradation. However, the analysis of time evolution shows, that contrary to the situations reported for SrO segregation in Sr-based perovskites, the Dchem is the coefficient mainly affected for compositions with inter-grown phases. At the same time, both Dchem and kchem decreases with time when only the tetragonal phase is present.